基于TPS63020的高效小型升降压电源技术
基于tps63020的高效小型升降压电源技术
tps6302x是ti 公司的高效小型升降压电源解决方案,输入电压从1.8v到5.5v,输出电流可高达3a,固定和可调输出电压从1.2v到5.5v,效率高达96%,能在降压和升压模式自动转换,静态电流小于50ua,固定工作频率2.4mhz,可用于所有两节和三节碱性电池, nicd 或nimh或单节锂电池供电的设备,超小型移动pc和mid,数码媒体播放器,dsc和摄像机.本文介绍了tps6302x主要特性,方框图, 可调输出电压典型应用电路图以及tps63020evm评估板特性,电路图和材料清单(bom).
the tps6302x devices provide a power supply solution for products powered by either a two-cell or three-cell alkaline, nicd or nimh battery, or a one-cell li-ion or li-polymer battery. output currents can go as high as 3a while using a single-cell li-ion or li-polymer battery, and discharge it down to 2.5v or lower. the buck-boost converter is based on a fixed frequency, pulse-width-modulation (pwm) controller using synchronous rectification to obtain maximum efficiency. at low load currents, the converter enters power save mode to maintain high efficiency over a wide load current range. the power save mode can be disabled, forcing the converter to operate at a fixed switching frequency. the maximum average current in the switches is limited to a typical value of 4a. the output voltage is programmable using an external resistor divider, or is fixed internally on the chip. the converter can be disabled to minimize battery drain. during shutdown, the load is disconnected from the battery. the device is packaged in a 14-pin qfn powerpad™ packagemeasuring 3 × 4 mm (dsj).
tps63020主要特性:
up to 96% efficiency
3a output current at 3.3v in step down mode (vin = 3.6v to 5.5v)
more than 2a output current at 3.3v in boost mode (vin > 2.5v)
automatic transition between step down and boost mode
dynamic input current limit
device quiescent current less than 50µa
input voltage range: 1.8v to 5.5v
fixed and adjustable output voltage options from 1.2v to 5.5v
power save mode for improved efficiency at low output power
forced fixed frequency operation at 2.4mhz and synchronization possible
smart power good output
load disconnect during shutdown
overtemperature protection
overvoltage protection
available in a 3 × 4-mm, qfn-14 package
tps63020应用:
all two-cell and three-cell alkaline, nicd or nimh or
single-cell li battery powered products
ultra mobile pc’s and mobile internet devices
digital media players
dsc’s and camcorders
图1.tps63020功能方框图
图2.tps63021功能方框图
图3.tps6302x可调输出电压典型应用电路图
tps63020evm评估板
the tps63020evm evaluation module (evm) is designed to help the user easily evaluate and test the operation and functionality of the tps63020. this user’s guide includes setup instructions for the hardware, a schematic diagram, a bill of materials, and printed-circuit board layout drawings for the evaluation module.
tps63020evm评估板主要性能表:
图4.tps63020evm-487评估板电路图
tps63020evm-487 材料清单(bom):
华为智慧屏如何持续领跑竞争新赛道？三大亮点值得关注
ABB 整体伺服系统解决方案：E530 伺服驱动器和DSM 伺服电机
美国6月将重归全球最快超算榜首
华为在新加坡设5G＋AI实验室 华为为巴西提供全栈云平台及AI能力
5G时代工业机器人已进入实证测试阶段
基于TPS63020的高效小型升降压电源技术
欧菲光短距毫米波雷达发布，提供全栈智能驾驶系统解决方案
Limitless和Lytro合作打造全新VR体验 高分辨率和光场是重点
TQ3568开发平台修改波特率
意大利空调市场持续下滑 海尔却增幅29%逆势高增长
高速与容错CAN在数据链路层内容及性能
北汽极狐坚守严苛的质量标准，赋予生活品质感
工业企业能耗在线监测通用技术研究及应用
整体销售效率提升50%，应用CRM为什么不能贪大求全？
iPad Pro性能无敌 但续航能力或将降低
工业机器人的RV减速器和谐波减速器到底有什么区别详细对比分析
电容式传感器和红外（IR）传感器应用原理
小米发布澎湃CPU和两款手机，小米MIX供货将改善，新旗舰小米6三月登场
华为P10疏油层、抽奖门、闪存门、WIFI门、内存门最新消息：问题门事件背后的秘密你知道吗？
商务部：对无人机实施出口管制是国际惯例 不针对任何特定国家和地区
tps6302x是ti 公司的高效小型升降压电源解决方案,输入电压从1.8v到5.5v,输出电流可高达3a,固定和可调输出电压从1.2v到5.5v,效率高达96%,能在降压和升压模式自动转换,静态电流小于50ua,固定工作频率2.4mhz,可用于所有两节和三节碱性电池, nicd 或nimh或单节锂电池供电的设备,超小型移动pc和mid,数码媒体播放器,dsc和摄像机.本文介绍了tps6302x主要特性,方框图, 可调输出电压典型应用电路图以及tps63020evm评估板特性,电路图和材料清单(bom).
the tps6302x devices provide a power supply solution for products powered by either a two-cell or three-cell alkaline, nicd or nimh battery, or a one-cell li-ion or li-polymer battery. output currents can go as high as 3a while using a single-cell li-ion or li-polymer battery, and discharge it down to 2.5v or lower. the buck-boost converter is based on a fixed frequency, pulse-width-modulation (pwm) controller using synchronous rectification to obtain maximum efficiency. at low load currents, the converter enters power save mode to maintain high efficiency over a wide load current range. the power save mode can be disabled, forcing the converter to operate at a fixed switching frequency. the maximum average current in the switches is limited to a typical value of 4a. the output voltage is programmable using an external resistor divider, or is fixed internally on the chip. the converter can be disabled to minimize battery drain. during shutdown, the load is disconnected from the battery. the device is packaged in a 14-pin qfn powerpad™ packagemeasuring 3 × 4 mm (dsj).
tps63020主要特性:
up to 96% efficiency
3a output current at 3.3v in step down mode (vin = 3.6v to 5.5v)
more than 2a output current at 3.3v in boost mode (vin > 2.5v)
automatic transition between step down and boost mode
dynamic input current limit
device quiescent current less than 50µa
input voltage range: 1.8v to 5.5v
fixed and adjustable output voltage options from 1.2v to 5.5v
power save mode for improved efficiency at low output power
forced fixed frequency operation at 2.4mhz and synchronization possible
smart power good output
load disconnect during shutdown
overtemperature protection
overvoltage protection
available in a 3 × 4-mm, qfn-14 package
tps63020应用:
all two-cell and three-cell alkaline, nicd or nimh or
single-cell li battery powered products
ultra mobile pc’s and mobile internet devices
digital media players
dsc’s and camcorders
图1.tps63020功能方框图
图2.tps63021功能方框图
图3.tps6302x可调输出电压典型应用电路图
tps63020evm评估板
the tps63020evm evaluation module (evm) is designed to help the user easily evaluate and test the operation and functionality of the tps63020. this user’s guide includes setup instructions for the hardware, a schematic diagram, a bill of materials, and printed-circuit board layout drawings for the evaluation module.
tps63020evm评估板主要性能表:
图4.tps63020evm-487评估板电路图
tps63020evm-487 材料清单(bom):
华为智慧屏如何持续领跑竞争新赛道？三大亮点值得关注
ABB 整体伺服系统解决方案：E530 伺服驱动器和DSM 伺服电机
美国6月将重归全球最快超算榜首
华为在新加坡设5G＋AI实验室 华为为巴西提供全栈云平台及AI能力
5G时代工业机器人已进入实证测试阶段
基于TPS63020的高效小型升降压电源技术
欧菲光短距毫米波雷达发布，提供全栈智能驾驶系统解决方案
Limitless和Lytro合作打造全新VR体验 高分辨率和光场是重点
TQ3568开发平台修改波特率
意大利空调市场持续下滑 海尔却增幅29%逆势高增长
高速与容错CAN在数据链路层内容及性能
北汽极狐坚守严苛的质量标准，赋予生活品质感
工业企业能耗在线监测通用技术研究及应用
整体销售效率提升50%，应用CRM为什么不能贪大求全？
iPad Pro性能无敌 但续航能力或将降低
工业机器人的RV减速器和谐波减速器到底有什么区别详细对比分析
电容式传感器和红外（IR）传感器应用原理
小米发布澎湃CPU和两款手机，小米MIX供货将改善，新旗舰小米6三月登场
华为P10疏油层、抽奖门、闪存门、WIFI门、内存门最新消息：问题门事件背后的秘密你知道吗？
商务部：对无人机实施出口管制是国际惯例 不针对任何特定国家和地区